Fuji FA-200 — fuji_fa200_KARI

Normal Operating Speeds at MTOW 2335lb reference

Take Off 15° Flap (Normal)
VR48 kts
Climb Out Clean Best Rate
VY71 kts
Cruise %Power
Keep engine temp below 200°C50-70
Max rpm2700
Landing Base Leg 15° Flap
Landing Base Leg 15° Flap78 kts
Final 35° Flap
Final 35° Flap70 kts
Threshold
Threshold65 kts
Max Crosswind
Max Crosswind15 kts
Stalling 35° Flaps
Stalling 35° Flaps50 kts
25° Flaps
VS152 kts
Clean
VSO59 kts
NOTEWarner operates @ 4-9 kts > stall
NOTECaution - Stall Speed increases sharply with bank angle
25° Flap stall speed @ 45° bank
25° Flap stall speed @ 45° bank63 kts
Clean stall speed @ 45° bank
Clean stall speed @ 45° bank70 kts
Minimum Windmill Glide
Minimum Windmill Glide82 kts
25° or 35° Flaps Extended
VFE103 kts
Design Maneuvering Speed
VA116 kts
15° Flaps Extended - White Arc
VFO121 kts
Normal Operations – Green Arc
VNO128 kts
Never Exceed – Red Line
VNE145 kts

Engine Failure During Takeoff Run takeoff

ThrottleIDLE
BrakesAPPLY
MixtureIDLE CUT-OFF
MagnetosOFF
Master SwitchOFF

Engine Failure Immediately After Takeoff takeoff

AirspeedMAINTAIN MIN 85 kts
Fuel Selector ValveSWITCH TANKS
Electric Fuel PumpON
MixtureRICH
Carburettor HeatON

Engine Failure During Flight engine_failure_in_flight

AirspeedMIN 85 kts
Carburettor HeatON
Electric Fuel PumpON
Fuel Selector ValveSWITCH TANKS
MixtureRICH
MagnetosBOTH
PrimerIN & LOCKED
Master SwitchON
NOTEIf engine failure was caused by fuel exhaustion, power will not be regained after tanks are switched until empty fuel lines are filled, which may require up to ten seconds.

Landing w/o Engine Power forced_landing

AirspeedMIN 85 kts ON FINALS
RadioMAYDAY on 121.5 MHz
MixtureIDLE CUT-OFF
Fuel Selector ValveOFF
MagnetosOFF
Master SwitchOFF
DoorOPEN
NOTETouchdown should be made at lowest possible airspeed with full flaps.

Electrical Fire in Flight electrical_fire

Master SwitchOFF
VentsOPEN
Cabin Heat and AirOFF
All ElectricsOFF
Master SwitchON
Switch on Essential EqptONE BY ONE
FireCHECK AFTER EACH ITEM
LandAS SOON AS POSSIBLE

Engine Fire in Flight engine_fire_in_flight

Fuel Selector ValveOFF
ThrottleCLOSED
MixtureIDLE CUT-OFF
Cabin Heat and AirOFF
DefrosterOFF
Forced LandingEXECUTE

Engine Fire During Start On Ground engine_fire_ground

CrankingCONTINUE
If Engine Starts:
Power1800 RPM for a few minutes
EngineSHUTDOWN & INSPECT
a. Fuel PumpOFF
b. Fuel SelectorOFF
c. Master SwitchOFF
d. MagnetosOFF
If Engine Fails to Start:
PassengersEVACUATE
EngineSECURE
a. Fuel PumpOFF
b. MixtureIDLE CUT-OFF
c. Master SwitchOFF
d. MagnetosOFF
e. Fuel Selector ValveOFF
FireEXTINGUISH

Cockpit preflight_inspection

Tech Log + Weight / BalanceCHECK
Tacho HoursCHECK & RECORD
TransparenciesCLEAN
Control LocksREMOVE
Fire ExtinguisherSECURE / GREEN ARC
First Aid KitPRESENT / SECURE
Master SwitchON
Fuel Quantity GaugesCHECK
Anti-Collision BeaconCHECK
Landing / Taxi LightsCHECK
Nav LightsCHECK
Stall WarnerCHECK
All Lighting SwitchesOFF
Master SwitchOFF
MagnetosOFF, KEYS REMOVED
Flaps40°

Port Wing preflight_inspection

Fuel TankDIP, CAP SECURE
Tank DrainDRAIN, SECURE
Fuel SamplePROPER COLOR
Gear, SpatSECURE / UNDAMAGED
TyreINFLATED – MARK ALIGNED
ChocksREMOVED
Wing Tip & LightUNDAMAGED
TiedownREMOVED
Pitot MastCLEAR / UNDAMAGED
AileronFREEDOM OF MOVEMENT
FlapSECURE & UNDAMAGED

Empennage preflight_inspection

AerialsSECURE
Static Vent (each side)CLEAR
StabilatorsFREEDOM OF MOVEMENT
RudderVISUAL CHECK ONLY
Anti-Balance / TrimSECURE, DAMAGE
Tail Cone & LightSECURE, UNDAMAGED
Tie DownREMOVED

Starboard Wing preflight_inspection

FlapSECURE / UNDAMAGED
AileronFREEDOM OF MOVEMENT
Wing Tip & LightUNDAMAGED
TiedownREMOVED
Fuel TankDIP, CAP SECURE
Tank DrainDRAIN, SECURE
Fuel SamplePROPER COLOR
Gear, SpatSECURE / UNDAMAGED
TyreINFLATED – MARK ALIGNED
ChocksREMOVED

Nose preflight_inspection

Engine Oil Level6 Qts. MIN, 8 Qts MAX
Engine Oil DipstickSECURE
CowlingSECURE, UNDAMAGED
Prop / SpinnerSECURE, UNDAMAGED
Alternator BeltPROPER TENSION
Nose OleoNO LEAKS / NORMAL
Spat / TyreCONDITION / DAMAGE
Tow BarREMOVED & STOWED
ChocksREMOVED
Fuel Sump DrainDRAIN, SECURE

Before Starting Engine before_start

Preflight InspectionCOMPLETE
FlapsUP IN STAGES
CanopyCLOSED / LOCKED
ControlsFULL & FREE MOVEMENT
Elevator TrimFULL TRAVEL – NEUTRAL
Fuel Selector ValveEMPTIEST TANK
Seats, HarnessesADJUSTED, LOCKED
Radio, Electrical EquipmentOFF
Parking BrakeSET
Circuit BreakersCHECK
Anti-Collision BeaconON

Engine Start (COLD) engine_start

Master SwitchON
MixtureFULL RICH
Fuel PumpON
Fuel PressureCHECK
Carburettor HeatFREE MOVEMENT - COLD
PrimeAS REQUIRED
ThrottleOPEN ¼ INCH
PropellerCLEAR
MagnetosSTART
Starter Engaged LightOUT
Oil PressureCHECK 25 psi MIN
EngineWARM UP 1200 RPM
BrakesHOLDING
Low Volts LightOUT
AmmeterCHARGING
SuctionREGISTERING
RadiosCOM 1 ON
NAV 1ON
COM 2ON
DMEON
TransponderSTANDBY
NAV 2ON
GPSON

Before Taxi before_taxi

RadiosCHECK VOLUME
GyrosERECTED
DIALIGN WITH COMPASS
AltimetersSET QFE / QNH
Nav LightsAS REQUIRED
Taxi LightON
Radio Check / Taxi ClearanceOBTAIN
Parking BrakeOFF

Taxi Checks taxi

Brakes / Nosewheel SteeringTEST
CompassSWINGING FREELY
DITURNING CORRECTLY
AIMOVING CORRECTLY
Turn / SlipMOVING CORRECTLY
ASIREGISTERING
Nav AidsREGISTERING

Power Checks before_takeoff

Parking BrakeSET
Fuel PumpON
Fuel PressureGREEN ARC
Fuel SelectorFULLEST TANK
Fuel PumpOFF
Fuel PressureGREEN ARC
Oil TemperatureYELLOW ARC MIN
Oil PressureCHECK 25 psi MIN
Area BehindCLEAR
ThrottleGENTLY INCREASE - 2000 RPM
Carburettor HeatHOT, CHECK RPM, COLD
MagnetosCHECK (150 RPM Max drop, 50 RPM diff.)
SuctionIN WHITE ARC
Oil TemperatureYELLOW ARC MIN
Oil PressureCHECK 25 psi MIN
Throttle - Idle500 – 700 RPM
Throttle1200 RPM SET

Pre-Takeoff before_takeoff

Elevator TrimSET NEUTRAL
Flaps15° (NORMAL)
Fuel ContentsSUFFICIENT
Carburettor HeatCOLD
PrimerLOCKED
Throttle FrictionFINGER TIGHT
MixtureFULL RICH
MagnetosBOTH
DIALIGN WITH COMPASS
AltimetersSET QFE / QNH
Radio AidsTUNE / IDENT
Engine Temps & PressureNORMAL
Fuel PumpON
Pitot HeaterAS REQUIRED
Nav LightsAS REQUIRED
Flight ControlsFULL & FREE
Hatches and HarnessesSECURE
Parking BrakeOFF
TransponderON-ALT
Departure ClearanceOBTAIN

Normal Takeoff takeoff

Flaps15° (NORMAL)
Carburettor HeatCOLD
Fuel PumpON
DIALIGNED WITH RUNWAY
Engine Temps & PressureNORMAL
ThrottleFULL OPEN
Rotate55 kts
Climb Speed71 kts
FlapsRETRACT 300ft MIN
Top of ClimbFREDAL CHECKS

Short Field / Obstacle Clearance takeoff

Flaps25° (Second Notch)
Carburetor HeatCOLD
Fuel PumpON
ThrottleFULL OPEN
Rotate55-60 kts
Initial Climb Speed71 kts

Climb climb

Normal Climb75 kts
VY – Best Rate of Climb Speed71 kts
VX – Best Angle of Climb Speed65 kts

Cruise cruise

Fuel PumpOFF
Power2200-2600 RPM
Elevator TrimSET
Taxi LightOFF
MixtureLEAN (MAX 200°C EGT)
Fuel SelectorSWITCH AS NEEDED

Before Landing before_landing

Parking BrakeOFF
MixtureFULL RICH
MagnetosBOTH
Fuel PumpON
Fuel SelectorFULLEST TANK
Engine Temps & PressureNORMAL
Carburettor HeatHOT
Seats / HarnessesADJUSTED / LOCKED
AirspeedIN WHITE ARC
FlapsAS REQUIRED
Airspeed80 kts
Elevator TrimSET
Landing LightON AS REQUIRED

Finals Checks approach

Carburettor HeatCOLD
RunwayCLEAR
ApproachSPEED & ANGLE OK
PermissionsLANDING CLEARANCE

After Landing after_landing

FlapsUP
Fuel PumpOFF
Landing LightOFF
Carburettor HeatOFF
TransponderOFF

Shut-Down, Securing Aeroplane shutdown

MagnetosCHECK LEFT / RIGHT
Electrical Equipment, LightsOFF
COM 1/2, NAV 1/2, DME, Xpdr, GPSOFF
ThrottleIDLE
MixtureIDLE CUT-OFF
IgnitionOFF
Master SwitchOFF
Parking BrakeSET (IF REQUIRED)
Chocks/TiedownsINSTALLED

Specifications reference

Maximum Gross Weight2335 lbs
Basic Empty Weight1575 lbs
Payload With Full Fuel448 lbs
Fuel Flow @ 75% Power8 gph
Total Fuel Capacity52 gal
Fuel Octane100LL (Blue)
Oil Sump Capacity8 qts

Fuji FA-200 — fuji_fa200_KARI_Checklist

Ratings & reviews

Normal Operating Speeds at MTOW 2335lb reference

Engine Failure During Takeoff Run takeoff

Engine Failure Immediately After Takeoff takeoff

Engine Failure During Flight engine_failure_in_flight

Landing w/o Engine Power forced_landing

Electrical Fire in Flight electrical_fire

Engine Fire in Flight engine_fire_in_flight

Engine Fire During Start On Ground engine_fire_ground

Cockpit preflight_inspection

Port Wing preflight_inspection

Empennage preflight_inspection

Starboard Wing preflight_inspection

Nose preflight_inspection

Before Starting Engine before_start

Engine Start (COLD) engine_start

Before Taxi before_taxi

Taxi Checks taxi

Power Checks before_takeoff

Pre-Takeoff before_takeoff

Normal Takeoff takeoff

Short Field / Obstacle Clearance takeoff

Climb climb

Cruise cruise

Before Landing before_landing

Finals Checks approach

After Landing after_landing

Shut-Down, Securing Aeroplane shutdown

Specifications reference

Download this checklist

Send yourself a preflight proof