Fuji FA-200 — fuji_fa200_KARI_Checklist NOT FOR FLIGHT — source fidelity: unreviewed | operational review: none | completeness: full Source: Fuji/FA-200/fuji_fa200_KARI_Checklist.txt Rights: licensed Checklist hash: 7cf7a72688a320a412e912f1a7f2bdc9701e6a4d3ceb1bf6b46fe7cabdfe0bb1 Verify against the aircraft's own approved documentation before use. ======================================================================== NORMAL OPERATING SPEEDS AT MTOW 2335LB -------------------------------------- TAKE OFF 15° FLAP (NORMAL) [ ] VR ........................................................... 48 kts CLIMB OUT CLEAN BEST RATE [ ] VY ........................................................... 71 kts CRUISE %POWER [ ] Keep engine temp below 200°C .................................. 50-70 [ ] Max rpm ........................................................ 2700 LANDING BASE LEG 15° FLAP [ ] Landing Base Leg 15° Flap .................................... 78 kts FINAL 35° FLAP [ ] Final 35° Flap ............................................... 70 kts THRESHOLD [ ] Threshold .................................................... 65 kts MAX CROSSWIND [ ] Max Crosswind ................................................ 15 kts STALLING 35° FLAPS [ ] Stalling 35° Flaps ........................................... 50 kts 25° FLAPS [ ] VS1 .......................................................... 52 kts CLEAN [ ] VSO .......................................................... 59 kts ** NOTE: Warner operates @ 4-9 kts > stall ** NOTE: Caution - Stall Speed increases sharply with bank angle 25° FLAP STALL SPEED @ 45° BANK [ ] 25° Flap stall speed @ 45° bank .............................. 63 kts CLEAN STALL SPEED @ 45° BANK [ ] Clean stall speed @ 45° bank ................................. 70 kts MINIMUM WINDMILL GLIDE [ ] Minimum Windmill Glide ....................................... 82 kts 25° OR 35° FLAPS EXTENDED [ ] VFE ......................................................... 103 kts DESIGN MANEUVERING SPEED [ ] VA .......................................................... 116 kts 15° FLAPS EXTENDED - WHITE ARC [ ] VFO ......................................................... 121 kts NORMAL OPERATIONS – GREEN ARC [ ] VNO ......................................................... 128 kts NEVER EXCEED – RED LINE [ ] VNE ......................................................... 145 kts ENGINE FAILURE DURING TAKEOFF RUN [EMERGENCY] ---------------------------------------------- [ ] Throttle ....................................................... IDLE [ ] Brakes ........................................................ APPLY [ ] Mixture ................................................ IDLE CUT-OFF [ ] Magnetos ........................................................ OFF [ ] Master Switch ................................................... OFF ENGINE FAILURE IMMEDIATELY AFTER TAKEOFF [EMERGENCY] ----------------------------------------------------- [ ] Airspeed ........................................ MAINTAIN MIN 85 kts [ ] Fuel Selector Valve .................................... SWITCH TANKS [ ] Electric Fuel Pump ............................................... ON [ ] Mixture ........................................................ RICH [ ] Carburettor Heat ................................................. ON ENGINE FAILURE DURING FLIGHT [EMERGENCY] ----------------------------------------- [ ] Airspeed ................................................. MIN 85 kts [ ] Carburettor Heat ................................................. ON [ ] Electric Fuel Pump ............................................... ON [ ] Fuel Selector Valve .................................... SWITCH TANKS [ ] Mixture ........................................................ RICH [ ] Magnetos ....................................................... BOTH [ ] Primer .................................................. IN & LOCKED [ ] Master Switch .................................................... ON ** NOTE: If engine failure was caused by fuel exhaustion, power will not be regained after tanks are switched until empty fuel lines are filled, which may require up to ten seconds. LANDING W/O ENGINE POWER [EMERGENCY] ------------------------------------- [ ] Airspeed ....................................... MIN 85 kts ON FINALS [ ] Radio ........................................... MAYDAY on 121.5 MHz [ ] Mixture ................................................ IDLE CUT-OFF [ ] Fuel Selector Valve ............................................. OFF [ ] Magnetos ........................................................ OFF [ ] Master Switch ................................................... OFF [ ] Door ........................................................... OPEN ** NOTE: Touchdown should be made at lowest possible airspeed with full flaps. ELECTRICAL FIRE IN FLIGHT [EMERGENCY] -------------------------------------- [ ] Master Switch ................................................... OFF [ ] Vents .......................................................... OPEN [ ] Cabin Heat and Air .............................................. OFF [ ] All Electrics ................................................... OFF [ ] Master Switch .................................................... ON [ ] Switch on Essential Eqpt ................................. ONE BY ONE [ ] Fire .......................................... CHECK AFTER EACH ITEM [ ] Land ............................................ AS SOON AS POSSIBLE ENGINE FIRE IN FLIGHT [EMERGENCY] ---------------------------------- [ ] Fuel Selector Valve ............................................. OFF [ ] Throttle ..................................................... CLOSED [ ] Mixture ................................................ IDLE CUT-OFF [ ] Cabin Heat and Air .............................................. OFF [ ] Defroster ....................................................... OFF [ ] Forced Landing .............................................. EXECUTE ENGINE FIRE DURING START ON GROUND [EMERGENCY] ----------------------------------------------- [ ] Cranking ................................................... CONTINUE IF ENGINE STARTS: [ ] Power .................................... 1800 RPM for a few minutes [ ] Engine ........................................... SHUTDOWN & INSPECT [ ] a. Fuel Pump .................................................. OFF [ ] b. Fuel Selector .............................................. OFF [ ] c. Master Switch .............................................. OFF [ ] d. Magnetos ................................................... OFF IF ENGINE FAILS TO START: [ ] Passengers ................................................. EVACUATE [ ] Engine ....................................................... SECURE [ ] a. Fuel Pump .................................................. OFF [ ] b. Mixture ........................................... IDLE CUT-OFF [ ] c. Master Switch .............................................. OFF [ ] d. Magnetos ................................................... OFF [ ] e. Fuel Selector Valve ........................................ OFF [ ] Fire ..................................................... EXTINGUISH COCKPIT ------- [ ] Tech Log + Weight / Balance ................................... CHECK [ ] Tacho Hours .......................................... CHECK & RECORD [ ] Transparencies ................................................ CLEAN [ ] Control Locks ................................................ REMOVE [ ] Fire Extinguisher ................................ SECURE / GREEN ARC [ ] First Aid Kit ...................................... PRESENT / SECURE [ ] Master Switch .................................................... ON [ ] Fuel Quantity Gauges .......................................... CHECK [ ] Anti-Collision Beacon ......................................... CHECK [ ] Landing / Taxi Lights ......................................... CHECK [ ] Nav Lights .................................................... CHECK [ ] Stall Warner .................................................. CHECK [ ] All Lighting Switches ........................................... OFF [ ] Master Switch ................................................... OFF [ ] Magnetos .......................................... OFF, KEYS REMOVED [ ] Flaps ........................................................... 40° PORT WING --------- [ ] Fuel Tank ........................................... DIP, CAP SECURE [ ] Tank Drain ............................................ DRAIN, SECURE [ ] Fuel Sample ............................................ PROPER COLOR [ ] Gear, Spat ....................................... SECURE / UNDAMAGED [ ] Tyre ........................................ INFLATED – MARK ALIGNED [ ] Chocks ...................................................... REMOVED [ ] Wing Tip & Light .......................................... UNDAMAGED [ ] Tiedown ..................................................... REMOVED [ ] Pitot Mast ........................................ CLEAR / UNDAMAGED [ ] Aileron ......................................... FREEDOM OF MOVEMENT [ ] Flap ............................................. SECURE & UNDAMAGED EMPENNAGE --------- [ ] Aerials ...................................................... SECURE [ ] Static Vent (each side) ....................................... CLEAR [ ] Stabilators ..................................... FREEDOM OF MOVEMENT [ ] Rudder ............................................ VISUAL CHECK ONLY [ ] Anti-Balance / Trim .................................. SECURE, DAMAGE [ ] Tail Cone & Light ................................. SECURE, UNDAMAGED [ ] Tie Down .................................................... REMOVED STARBOARD WING -------------- [ ] Flap ............................................. SECURE / UNDAMAGED [ ] Aileron ......................................... FREEDOM OF MOVEMENT [ ] Wing Tip & Light .......................................... UNDAMAGED [ ] Tiedown ..................................................... REMOVED [ ] Fuel Tank ........................................... DIP, CAP SECURE [ ] Tank Drain ............................................ DRAIN, SECURE [ ] Fuel Sample ............................................ PROPER COLOR [ ] Gear, Spat ....................................... SECURE / UNDAMAGED [ ] Tyre ........................................ INFLATED – MARK ALIGNED [ ] Chocks ...................................................... REMOVED NOSE ---- [ ] Engine Oil Level .............................. 6 Qts. MIN, 8 Qts MAX [ ] Engine Oil Dipstick .......................................... SECURE [ ] Cowling ........................................... SECURE, UNDAMAGED [ ] Prop / Spinner .................................... SECURE, UNDAMAGED [ ] Alternator Belt ...................................... PROPER TENSION [ ] Nose Oleo ......................................... NO LEAKS / NORMAL [ ] Spat / Tyre ...................................... CONDITION / DAMAGE [ ] Tow Bar ............................................ REMOVED & STOWED [ ] Chocks ...................................................... REMOVED [ ] Fuel Sump Drain ....................................... DRAIN, SECURE BEFORE STARTING ENGINE ---------------------- [ ] Preflight Inspection ....................................... COMPLETE [ ] Flaps .................................................. UP IN STAGES [ ] Canopy .............................................. CLOSED / LOCKED [ ] Controls ....................................... FULL & FREE MOVEMENT [ ] Elevator Trim ................................. FULL TRAVEL – NEUTRAL [ ] Fuel Selector Valve ................................... EMPTIEST TANK [ ] Seats, Harnesses ................................... ADJUSTED, LOCKED [ ] Radio, Electrical Equipment ..................................... OFF [ ] Parking Brake ................................................... SET [ ] Circuit Breakers .............................................. CHECK [ ] Anti-Collision Beacon ............................................ ON ENGINE START (COLD) ------------------- [ ] Master Switch .................................................... ON [ ] Mixture ................................................... FULL RICH [ ] Fuel Pump ........................................................ ON [ ] Fuel Pressure ................................................. CHECK [ ] Carburettor Heat ............................... FREE MOVEMENT - COLD [ ] Prime ................................................... AS REQUIRED [ ] Throttle ................................................ OPEN ¼ INCH [ ] Propeller ..................................................... CLEAR [ ] Magnetos ...................................................... START [ ] Starter Engaged Light ........................................... OUT [ ] Oil Pressure ....................................... CHECK 25 psi MIN [ ] Engine ............................................. WARM UP 1200 RPM [ ] Brakes ...................................................... HOLDING [ ] Low Volts Light ................................................. OUT [ ] Ammeter .................................................... CHARGING [ ] Suction ................................................. REGISTERING [ ] Radios ..................................................... COM 1 ON [ ] NAV 1 .......................................................... ON [ ] COM 2 .......................................................... ON [ ] DME ............................................................ ON [ ] Transponder ............................................... STANDBY [ ] NAV 2 .......................................................... ON [ ] GPS ............................................................ ON BEFORE TAXI ----------- [ ] Radios ................................................. CHECK VOLUME [ ] Gyros ....................................................... ERECTED [ ] DI ............................................... ALIGN WITH COMPASS [ ] Altimeters ............................................ SET QFE / QNH [ ] Nav Lights .............................................. AS REQUIRED [ ] Taxi Light ....................................................... ON [ ] Radio Check / Taxi Clearance ................................. OBTAIN [ ] Parking Brake ................................................... OFF TAXI CHECKS ----------- [ ] Brakes / Nosewheel Steering .................................... TEST [ ] Compass ............................................. SWINGING FREELY [ ] DI ................................................ TURNING CORRECTLY [ ] AI ................................................. MOVING CORRECTLY [ ] Turn / Slip ........................................ MOVING CORRECTLY [ ] ASI ..................................................... REGISTERING [ ] Nav Aids ................................................ REGISTERING POWER CHECKS ------------ [ ] Parking Brake ................................................... SET [ ] Fuel Pump ........................................................ ON [ ] Fuel Pressure ............................................. GREEN ARC [ ] Fuel Selector .......................................... FULLEST TANK [ ] Fuel Pump ....................................................... OFF [ ] Fuel Pressure ............................................. GREEN ARC [ ] Oil Temperature ...................................... YELLOW ARC MIN [ ] Oil Pressure ....................................... CHECK 25 psi MIN [ ] Area Behind ................................................... CLEAR [ ] Throttle ................................. GENTLY INCREASE - 2000 RPM [ ] Carburettor Heat ............................... HOT, CHECK RPM, COLD [ ] Magnetos ..................... CHECK (150 RPM Max drop, 50 RPM diff.) [ ] Suction ................................................ IN WHITE ARC [ ] Oil Temperature ...................................... YELLOW ARC MIN [ ] Oil Pressure ....................................... CHECK 25 psi MIN [ ] Throttle - Idle ....................................... 500 – 700 RPM [ ] Throttle ............................................... 1200 RPM SET PRE-TAKEOFF ----------- [ ] Elevator Trim ........................................... SET NEUTRAL [ ] Flaps .................................................. 15° (NORMAL) [ ] Fuel Contents ............................................ SUFFICIENT [ ] Carburettor Heat ............................................... COLD [ ] Primer ....................................................... LOCKED [ ] Throttle Friction ...................................... FINGER TIGHT [ ] Mixture ................................................... FULL RICH [ ] Magnetos ....................................................... BOTH [ ] DI ............................................... ALIGN WITH COMPASS [ ] Altimeters ............................................ SET QFE / QNH [ ] Radio Aids ............................................. TUNE / IDENT [ ] Engine Temps & Pressure ...................................... NORMAL [ ] Fuel Pump ........................................................ ON [ ] Pitot Heater ............................................ AS REQUIRED [ ] Nav Lights .............................................. AS REQUIRED [ ] Flight Controls ......................................... FULL & FREE [ ] Hatches and Harnesses ........................................ SECURE [ ] Parking Brake ................................................... OFF [ ] Transponder .................................................. ON-ALT [ ] Departure Clearance .......................................... OBTAIN NORMAL TAKEOFF -------------- [ ] Flaps .................................................. 15° (NORMAL) [ ] Carburettor Heat ............................................... COLD [ ] Fuel Pump ........................................................ ON [ ] DI .............................................. ALIGNED WITH RUNWAY [ ] Engine Temps & Pressure ...................................... NORMAL [ ] Throttle .................................................. FULL OPEN [ ] Rotate ....................................................... 55 kts [ ] Climb Speed .................................................. 71 kts [ ] Flaps ............................................. RETRACT 300ft MIN [ ] Top of Climb .......................................... FREDAL CHECKS SHORT FIELD / OBSTACLE CLEARANCE -------------------------------- [ ] Flaps ............................................ 25° (Second Notch) [ ] Carburetor Heat ................................................ COLD [ ] Fuel Pump ........................................................ ON [ ] Throttle .................................................. FULL OPEN [ ] Rotate .................................................... 55-60 kts [ ] Initial Climb Speed .......................................... 71 kts CLIMB ----- [ ] Normal Climb ................................................. 75 kts [ ] VY – Best Rate of Climb Speed ................................ 71 kts [ ] VX – Best Angle of Climb Speed ............................... 65 kts CRUISE ------ [ ] Fuel Pump ....................................................... OFF [ ] Power ................................................. 2200-2600 RPM [ ] Elevator Trim ................................................... SET [ ] Taxi Light ...................................................... OFF [ ] Mixture ........................................ LEAN (MAX 200°C EGT) [ ] Fuel Selector ...................................... SWITCH AS NEEDED BEFORE LANDING -------------- [ ] Parking Brake ................................................... OFF [ ] Mixture ................................................... FULL RICH [ ] Magnetos ....................................................... BOTH [ ] Fuel Pump ........................................................ ON [ ] Fuel Selector .......................................... FULLEST TANK [ ] Engine Temps & Pressure ...................................... NORMAL [ ] Carburettor Heat ................................................ HOT [ ] Seats / Harnesses ................................. ADJUSTED / LOCKED [ ] Airspeed ............................................... IN WHITE ARC [ ] Flaps ................................................... AS REQUIRED [ ] Airspeed ..................................................... 80 kts [ ] Elevator Trim ................................................... SET [ ] Landing Light ........................................ ON AS REQUIRED FINALS CHECKS ------------- [ ] Carburettor Heat ............................................... COLD [ ] Runway ........................................................ CLEAR [ ] Approach ........................................... SPEED & ANGLE OK [ ] Permissions ....................................... LANDING CLEARANCE AFTER LANDING ------------- [ ] Flaps ............................................................ UP [ ] Fuel Pump ....................................................... OFF [ ] Landing Light ................................................... OFF [ ] Carburettor Heat ................................................ OFF [ ] Transponder ..................................................... OFF SHUT-DOWN, SECURING AEROPLANE ----------------------------- [ ] Magnetos ......................................... CHECK LEFT / RIGHT [ ] Electrical Equipment, Lights .................................... OFF [ ] COM 1/2, NAV 1/2, DME, Xpdr, GPS ................................ OFF [ ] Throttle ....................................................... IDLE [ ] Mixture ................................................ IDLE CUT-OFF [ ] Ignition ........................................................ OFF [ ] Master Switch ................................................... OFF [ ] Parking Brake ..................................... SET (IF REQUIRED) [ ] Chocks/Tiedowns ........................................... INSTALLED SPECIFICATIONS -------------- [ ] Maximum Gross Weight ....................................... 2335 lbs [ ] Basic Empty Weight ......................................... 1575 lbs [ ] Payload With Full Fuel ...................................... 448 lbs [ ] Fuel Flow @ 75% Power ......................................... 8 gph [ ] Total Fuel Capacity .......................................... 52 gal [ ] Fuel Octane ............................................ 100LL (Blue) [ ] Oil Sump Capacity ............................................. 8 qts